large capacitance aluminum electrolytic capacitors long life screw terminals ,105 c cat. no. e1001d @ rated voltage range up to 525v dc @ endurance with ripple current : 105 c 5000 hours (2000 hours for 500v dc & 525v dc ) @ high reliability products ? specifications (at 20 c , 120hz) (at 20 c after 5 minutes) (at 20 c , 120hz) (at 120hz) category temperature range rated voltage range capacitance tolerance leakage current dissipation factor (tan e ) low temperature characteristics insulation resistance insulation withstanding voltage endurance shelf life items - 40 to +105 c (10 to 100v dc ) - 25 to +105 c (160 to 525v dc ) 10 to 525v dc - 10 to +50% (t) (10 to 250v dc ) p 20% (m) (350 to 525v dc ) i=0.02cv or 5ma, whichever is smaller. where, i : max. leakage current ( m a), c : nominal capacitance ( m f), v : rated voltage (v) see standard ratings (10 to 250v dc ) 0.20max (350 to 525v dc ) capacitance change c(-40 c )/c(+20 c ) ] 0.6(10 to 100v dc ) c(-25 c )/c(+20 c ) ] 0.7(160 to 250v dc ) c(-25 c )/c(+20 c ) ] 0.65(350 to 525v dc ) when measured between the terminals shorted each other and the mounting clamp on the insulating sleeve covering the case by usi ng an insulation resistance meter of 500vdc, the insulation resistance shall not be less than 100m o . when a voltage of 2000vac is applied for 1 minute between the terminals shorted each other and the mounting clamp on the insula ting sleeve covering the case, there shall not be electrical damage. the following specifications shall be satisfied when the capacitors are restored to 20 c after dc voltage with the rated ripple current is applied for 5000 hours (2000 hours for 500 & 525v dc products) at 105 c . capacitance change [p 20% of the initial value d.f. (tan e ) [ 200% of the initial specified value leakage current [ the initial specified value the following specifications shall be satisfied when the capacitors are restored to 20 c after exposing them for 1000 hours at 105 c without voltage applied. rated voltage capacitance change [p 15% of the initial value d.f. (tan e ) [ 150% of the initial specified value leakage current [ the initial specified value characteristics 10 to 250v dc 350 to 525v dc [p 20% of the initial value [ 200% of the initial specified value [ the initial specified value ? part numbering system lxa 450 lgsn 3300 m c e10r case code type of mounting clamp, if required capacitance tolerance nominal capacitance in m f screw terminal type rated voltage in volts series name *capacitance tolerance t : 10 to 250v dc m : 350 to 525v dc ? dimensions (terminal type=lgsn) [mm] @ b type of mounting clamp * the screw and the mounting clamp are separately supplied and not attached to the product. l+4max. g p 1 sleeve f d+1.8max. f p 1 6 a p 1 w p 1 h b p 1 30 p 5 p 5 p 1 e p 1 4.5 @ c type of mounting clamp f d 35 50 63.5 76 a 58 78 90 104.5 b 44 64 76 90 w 48 68 80 93.5 h 3.5 4.5 4.5 4.5 f 12.7 22.4 28.0 31.5 f d 50 63.5 76 89 e 32.5 38.1 44.5 50.8 k 37.0 43.5 50.0 56.5 j 14.0 14.0 14.0 16.0 f 22.4 28.0 31.5 31.5 plus hexagon-headed screw: m5 b 0.8 b 10 maximum screw tightening torque: 3.23nm 35 50 63.5 76 89 a5 - - - - 50 60 80 85 100 - c6 - - - a8 c8 - - - - c8r d8r e8r - a10 c10 d10 e10 - - c10r d10r e10r - a12 c12 d12 e12 - - c12r d12r e12r f12r - - - e14 f14 - c14r d14r e14r f14r - - - e19 f19 - - - - f27 105 120 125 140 145 190 270 l (mm) f d (mm) ? case code f d kf 63.5 f 76 f 89 10 to 250v dc 6 5 5 350 to 525v dc 6 6 4 g (1/4)
large capacitance aluminum electrolytic capacitors long life screw terminals ,105 c cat. no. e1001d 2,200 2,700 3,300 3,900 4,700 5,600 6,800 8,200 10,000 12,000 15,000 18,000 22,000 27,000 33,000 39,000 47,000 56,000 68,000 82,000 100,000 120,000 150,000 180,000 220,000 270,000 330,000 390,000 10 13 16 20 25 32 35 44 50 63 63 79 80 100 sv v dc m f a8 a8 a8 a10 a10 a12 c8 c10 c10 d10 d10 e10 e12 e14 f14 4.3 4.7 5.3 6.1 6.2 6.8 7.8 8.5 9.5 11.0 12.1 13.2 14.4 17.0 18.6 0.45 0.45 0.45 0.45 0.50 0.60 0.60 0.70 0.70 0.80 0.80 1.00 1.20 1.20 1.40 a5 a8 a8 a8 a10 a10 a12 c8 c10 c12 c12 d10 e10 e12 e14 f14 2.9 3.5 3.9 4.3 4.8 5.3 6.2 6.3 7.6 8.3 9.2 9.9 12.3 14.5 15.2 16.8 0.45 0.45 0.45 0.45 0.50 0.50 0.50 0.60 0.60 0.70 0.70 0.80 0.80 0.80 1.00 1.20 a8 a8 a8 a8 a10 a12 c8 c10 c12 c12 d10 d12 e10 e12 e14 f14 3.3 3.7 4.0 4.5 5.0 5.9 6.5 7.9 8.8 9.1 10.6 11.4 12.8 13.7 16.1 16.6 0.35 0.35 0.35 0.35 0.40 0.40 0.40 0.40 0.40 0.50 0.50 0.60 0.60 0.75 0.75 1.00 a8 a8 a8 a8 a10 a12 c8 c10 c12 c12 d10 d12 e12 e14 f14 3.0 3.3 3.6 4.1 4.8 5.2 5.9 6.6 7.8 8.0 9.2 11.0 12.7 13.5 16.1 0.30 0.30 0.30 0.30 0.30 0.35 0.40 0.40 0.40 0.45 0.45 0.45 0.50 0.60 0.60 a5 a5 a8 a8 a8 a8 a10 a12 c8 c10 c12 d10 d12 d12 e12 e14 f14 2.0 2.2 2.8 3.0 3.3 3.7 4.4 4.7 4.8 5.9 7.0 7.6 8.9 9.8 11.9 13.1 14.8 0.20 0.25 0.25 0.25 0.25 0.25 0.25 0.30 0.35 0.35 0.35 0.40 0.40 0.40 0.40 0.45 0.50 a5 a5 a8 a8 a8 a8 a10 a12 c8 c10 c12 c12 d12 e10 e12 e14 f14 1.9 2.1 2.7 2.9 3.2 3.5 4.2 4.3 4.8 5.9 6.3 6.7 8.8 10.0 10.7 12.5 13.8 0.15 0.15 0.20 0.20 0.20 0.20 0.20 0.25 0.25 0.25 0.25 0.30 0.30 0.30 0.35 0.35 0.40 a5 a8 a8 a8 a10 a10 a12 c8 c10 c10 c12 d12 e10 e12 e14 f14 1.9 2.2 2.5 2.9 3.1 3.5 4.1 4.8 5.6 6.1 7.4 8.0 9.1 9.7 11.5 12.5 0.15 0.15 0.15 0.15 0.15 0.15 0.20 0.20 0.20 0.20 0.20 0.25 0.25 0.30 0.30 0.35 case code rated ripple current (arms) at 105 c , 120hz max. tan e at 20 c , 120hz ? standard ratings 330 390 470 560 680 820 1,000 1,200 1,500 1,800 2,200 2,700 3,300 3,900 4,700 5,600 6,800 8,200 10,000 12,000 15,000 18,000 22,000 27,000 100 125 160 200 200 250 250 300 sv v dc m f a5 a8 a8 a8 a8 a10 a12 c8 c10 c12 c12 d10 d12 e10 e12 e14 f14 1.4 1.6 1.8 2.0 2.4 2.8 3.1 3.6 4.3 5.0 5.5 6.4 6.6 7.5 8.0 9.4 10.4 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.20 0.20 0.25 0.25 0.30 a5 a8 a8 a8 a8 a10 a12 a12 c10 c12 c12 c12 d12 e10 e12 e14 f14 1.1 1.2 1.3 1.5 1.7 2.0 2.3 2.7 3.3 3.8 4.2 4.7 5.7 6.4 6.6 7.8 9.5 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.20 0.20 0.20 0.20 a5 a8 a8 a8 a10 a12 a12 c8 c10 c12 c12 d10 d12 e10 e12 e14 f14 0.9 1.0 1.1 1.3 1.5 1.7 1.9 2.2 2.7 3.2 3.5 4.0 4.7 5.3 6.3 6.4 7.7 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.20 0.20 a5 a8 a8 a8 a10 a10 a12 c8 c10 c12 c12 d10 d12 e10 e12 e14 f14 0.7 0.8 0.9 1.0 1.2 1.4 1.6 1.8 2.2 2.6 2.8 3.3 4.0 4.4 5.2 6.1 7.4 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 0.15 max. tan e at 20 c , 120hz rated ripple current (arms) at 105 c , 120hz case code (2/4)
large capacitance aluminum electrolytic capacitors long life screw terminals ,105 c cat. no. e1001d 350 400 400 450 450 500 50 b 60 50 b 85 50 b 105 50 b 125 50 b 145 63.5 b 85 63.5 b 105 63.5 b 125 63.5 b 145 76 b 85 76 b 105 76 b 125 76 b 145 76 b 190 89 b 125 89 b 145 89 b 190 89 b 270 820 1,500 2,200 2,700 3,300 2,700 3,300 3,900 5,600 3,900 6,800 8,200 10,000 8,200 10,000 15,000 22,000 680 1,200 1,800 2,200 2,700 2,200 2,700 3,300 4,700 3,300 4,700 6,800 8,200 6,800 8,200 12,000 18,000 560 1,000 1,200 1,800 2,200 1,800 2,200 2,700 3,300 2,700 3,300 3,900 4,700 6,800 5,600 6,800 10,000 15,000 3.3 5.2 7.0 8.4 9.9 8.1 9.8 11.5 14.7 10.8 16.8 19.6 23.0 18.9 22.2 30.6 43.5 3.0 4.7 6.3 7.5 8.9 7.3 8.8 10.5 13.4 9.9 13.9 17.9 20.8 17.2 20.1 27.4 39.4 2.6 4.0 4.8 6.4 7.6 6.2 7.5 8.9 10.6 8.4 10.2 11.9 14.0 17.3 14.2 16.7 22.8 32.8 500 550 525 575 50 b 60 50 b 85 50 b 105 50 b 125 50 b 145 63.5 b 85 63.5 b 105 63.5 b 125 63.5 b 145 76 b 85 76 b 105 76 b 125 76 b 145 76 b 190 89 b 125 89 b 145 89 b 190 89 b 270 470 820 1,000 1,200 1,500 1,200 1,800 2,700 2,700 3,900 3,900 6,800 10,000 390 680 1,000 1,500 1,800 2,200 2,200 2,700 3,300 4,700 4,700 5,600 2.4 3.6 4.4 5.2 6.3 5.0 6.8 9.6 9.2 12.7 11.9 18.8 26.8 2.2 3.3 4.8 6.2 7.3 8.6 8.3 9.9 11.7 14.4 13.9 17.1 v dc sv items case size f d b l (mm) capacitance ( m f) 20 c , 120hz rated ripple current (arms) 105 c , 120hz capacitance ( m f) 20 c , 120hz rated ripple current (arms) 105 c , 120hz v dc sv items case size f d b l (mm) capacitance ( m f) 20 c , 120hz rated ripple current (arms) 105 c , 120hz capacitance ( m f) 20 c , 120hz rated ripple current (arms) 105 c , 120hz capacitance ( m f) 20 c , 120hz rated ripple current (arms) 105 c , 120hz ? standard ratings (3/4)
large capacitance aluminum electrolytic capacitors long life screw terminals ,105 c cat. no. e1001d ? rated ripple current multipliers @ frequency multiplirs note : the endurance of capacitors is shorted with internal heating produced by ripple currents at the rate of halving the life time with every 5 to 10 c rise. when long life performance is requested in actual use, the rms ripple current has to be reduced. also, for the lxa series capacitors (350 to 525v dc products), using them at operating voltage can extend their lifetime. for the detail, please contact a representative of nippon chemi-con. 50 0.95 0.90 0.80 120 1.00 1.00 1.00 300 1.03 1.06 1.12 1k 1.05 1.10 1.22 10k 1.09 1.18 1.30 50k 1.12 1.22 1.33 frequency (hz) 10 to 50v dc 63 to 80v dc 100 to 250v dc (10 to 250v dc ) frequency (hz) coefficient 120 1.0 50 0.8 300 1.2 1k 1.5 3k 1.6 (350 to 525v dc ) (4/4)
|
